Optimus Prime. The Autobot leader.

While I enjoyed the stunning CGI effects and battle scenes I could not help but notice that the humans soldiers, a mixture of British and American special forces, were getting a very raw deal. They were being sent into battle armed with M16s against robots that are about 20-30 feet in height and made out of metal.

Taking some serious punishment from the Decepticons

What the Robot Fighting Warriors were Carrying

I did not pay much attention to the weaponry as I normally do when watching a movie because I was enjoying all the special effects, but if my memory serves me correctly the human were all armed with M16 rifles that featured some funky, almost triangular, handguard. Below the handguard they had a fore-grip with light attachment. I cannot remember if there were any M203 grenade launchers. If there were they were not using them much.

Major William Lennox (left), leader of the humans, on the run.

The M16 fires the 5.56mm NATO round which is an intermediate (low power) rifle cartridge. Although an armor piercing variant is available, it was never intended as an anti-vehicle round. It is not even considered powerful enough to hunt deer, let alone robots.

How to Destroy a Robot

One word: Power. Lots and lots of pure armor destroying power. Forget about pistols, which can be seen dangling off the legs of the soldiers in the above photo. Forget about low powered assault rifles. Leave them at home.

For most anti-robot needs we must turn to South Africa. Because of the oppressive apartheid régime in South Africa during latter half of the 20th century, arms embargoes were levied against the country. The arms embargoes from Western countries combined with a proxy war in Angola against the Soviets meant that the South African arms industry developed in isolation. The isolation resulted in a variety of unique and very powerful, some would say overkill, small arms.

1. PMP Neopup PAW – 20mm Personal Assault Weapon

The Neopup PAW (Personal Assault Weapon) is manufactured by South African firm Denel. It is a semi-automatic 20mm grenade launcher. As far as I know it is the only semi-automatic grenade launcher designed explicitly to replace a rifle in the hands of a soldier, unlike the XM25 (I believe XM25 operators would carry an M4 or equivalent weapon).

The older variant of the Neopup.

The latest model. Note the more compact curved magazine.

The Neopup fires high explosive 20×42mm grenades. These grenades are designed to have a very flat trajectory, allowed you operator to point and shoot, rather than lobbing shells into the air on a steep trajectory. This is what makes it the perfect robot killer. The user simply needs to aim at the head, neck, chest or any other venerable area and fire a HE (High explosive) round to do some serious damage. Try doing that with an M16! I propose the robot warriors dump their rifles and pick up Neopup PAW.

20mm grenade 20×42 vs. 40mm grenade trajectory.

2. Milkor MGL – 40mm Multiple Grenade Launcher

While the 20mm grenade launcher may offer fast reloading and more accurate shooting, outfitting grenadiers with 40mm “artillery” could turn the tide of a battle.

The Milkor MGL has an interesting history. It is basically a scaled up version of the infamous South African Armsel Striker aka. the Protecta aka. the Street Sweeper 12 gauge shotgun. The design made for a scary looking but very inefficient shotgun. Another South African firm, Milkor, scaled it up from 12 guage to 40mm and developed a very successful multiple grenade launcher that was recently adopted by the US Marines as the M32 MGL.

A Marine with the M32 in Iraq.

The weapon can fire six 40×46mm grenades as fast as the operator can pull the trigger, although aimed fired from this heavy recoil weapon does slow down the effective firing rate. At relatively close range a trained operator should be able to hit a Decepticon robot and a high explosive round would do considerable damage. It can also be used to lay down indirect fire much like a mortar.

3. Denel NTW-20 – Long Range Anti-Robot Sniper Rifle

Denel also produces the enormous NTW-20 anti-material rifle. This rifle can be configured to fire the Semi-Armour Piercing High Explosive Incendiary (SAPHEI) 20×82mm rounds or the 14.5×114 mm Armour Piercing Incendiary (API).

Click to expand the image.


A better sense of scale. It is huge!

This weapon is more than twice as powerful as .50 BMG (12.7×99mm NATO) rifles! It can accuracy fire out past 1000 meters taking the fight to the enemy before than are in range.

The reason I chose the NTW-20 over other anti-material rifles is that is can quickly be broken down in half for portability.

Being carried by a two man team.

4. Metal Storm MAUL: A pistol that packs a punch

A couple of months ago the Australian firm Metal Storm unveiled the MAUL. It is a lightweight semi-automatic shotgun that is being funded by the US Navy. The unique Metal Storm technology stores the ammunition inside the barrel and then electronically fires it one round at a time. This allows for a shotgun so compact, it can be configured as a pistol!

While this would be no-where as powerful as a full-sized shotgun, due to the short barrel length, if it was loaded with 12 guage grenades it would pack a punch orders of magnitude more powerful than a conventional pistol making it a perfect last ditch defense side-arm to use against ranpaging robots.

5. RPG-7: An oldie but a goodie

This weapon needs no introduction. The Soviet designed RPG-7 is by far the most well known and recognizable grenade launcher and is favored by third world armies, rebels and terrorists.

An Afghan policeman being taught how to use the RPG-7

So why would a nearly 50 year old weapon make a good robot killer? Versatility. The large size of the warhead allows for a wide variety of ammunition.

Different RPG-7 ammunition.

Currently high explosive anti-amour, tandem anti-armour (two charges fired in tandem to defeat reactive armor), fragmentation and even thermobaric ammunition is available. The RPG-7 would make a perfect platform for an anti-Robot weapon such as some sort of Electromagnetic pulse (EMP) device.

Conclusion

The troops in Transformers 2 were very poorly armed. If an alien race of robots landed on earth today, any half-decent arms dealer could could supply much better weapons that what the script writers of the movie came up with.

Hopefully the producers will hire me as a technical consultant before the next Transformers movie comes out

[ Don't take this blog post seriously ]

The armor.

The holes, or the edges of the holes, deflect bullets making them tumble so the “blunt” side hits the armor instead of the front. This spreads out the kinetic energy over the length of the bullet instead of it being concentrated at the front.

I don’t think this would have any effect on shaped charges, which are a mass of hot metal (usually copper), so this type of armor would probably be used in vehicles that would not be armored against shaped charges, such as RPG rounds, in the first place, for example VIP transport vehicles.

RPG-7 launcher and grenade.

From the press release:

It may seem like a strange solution but introducing holes to vehicle armour can actually provide a ective advantage. The trick is to think of them as circular ‘edges’ rather than holes. When a bullet hits an edge, it gets deflected and turns from a sharp projectile into a blunt fragment which makes it much easier to stop. The introduction of holes also reduces weight. As a result perforated Super Bainite steel armour is ballistically very efficient.

Invented, designed and manufactured in the UK, Super Bainite is experimental high performance armour steel developed to save the lives of UK Armed Forces. Traditionally the MOD has utilised offshore suppliers to fulfil its specialist armour requirements. However, following successful industrial production trials, directed by Dstl in partnership with Corus and Bodycote, the UK is now well placed to develop a secure onshore supply of specialist, high hardness steel armour.

Hat Tip: Defense Talk and “null”.

The Australian reports:

A ROCKET launcher and nine grenades have been found in the luggage of a passenger on a flight in Papua New Guinea.

…

Police seized the weapon and ammunition after discovering them at the Mt Hagen airport in PNG’s Highlands region last Wednesday.

They also discovered a scope that is believed to be part of the rocket launcher.

…

PNG’s Highlands region is infamous for sometimes decades-long tribal fights.

I have held a deactivated RPG round. They are heavy! I would not want to try carrying nine of them in a suitcase without looking suspicious.

In the context of a December 2006 deal, valued at 330 million USD with the US company Raytheon, Soukos Robots S.A. began to export products (kits) of special anti- RPG technology that is intended for the protection of combat vehicles and helicopters of the US Army. The effectiveness of the technology in question was confirmed after certified and successful trials were carried out in firing ranges in the USA. At this point it deserves to mark the continuous support of the hellenic MoD and more specifically the defence aquisitions directorate (ΓΔΑΕΕ).

It appears to be be an evolution of slat/cage armor. The Patent has information on how it works:

It comprises of a protective grid (12) of special configuration and hardness. In the interspaces (19) of the grid (12) there exists a polyester foam (13) for its adequate electrical insulation. The grid (12) possesses a serrate conductive entrance (14) on the side of rocket impact (40) and a conductive cathode (15) on its other side. All the electrodes (23) are connected with an electronic control unit (16) in order for the data to be transferred from the impact surfaces to this unit. The unit (16) is programmed to terminate the electric energy produced by the piezoelectric crystal to an ignition head of the Rocket Propelled Grenade RPG when this rocket strikes against the conductive entrance (14) of the protective grid (12). It can be used for the protection against the lethal Rocket propelled grenades RPG.

The saw-tooth armor design.

In summery: the saw-tooth armor carries a current sufficient enough to “shock” the piezoelectric transducer (the component which, when it hits something, causes the fuse to ignite) and so detonates the grenade early. The steel saw-tooth armor is designed in much away that it spreads out the explosion. Since it works against anti-armor grenades, I assume it disrupts the shaped charge. How it does this is beyond my understanding. If you have any ideas, please share them in the comments.

This technology has been talked about for some time, it is good to see it finally shipping.

More from the patent after the jump.

conductive cathode (15) at the other side of the net (11) , one at least appropriate connection plug (17) and a control unit (16) . Protection system against self- propelled grenades is characterized by the fact that it has the ability, during the impact of the rocket grenade at its first sensitive layer, which is the tooth shaped conductive entrance (14) , to destroy and interrupt the ■ electric power produced by the piezoelectric crystal that is placed at the firing head of the rocket grenade.

The system is characterized by the fact it protects all types of vehicles, public and private property, helicopters, airplanes in the ground of military use or not, various buildings, human’s transportation means, as well as radar units by terrorist and hostile action, where the risk of the launched rocket grenades is huge, for the human lives as well as for the material possessions .

In accordance with another feature of the invention, the layers (13, 14, 15) that it consists of contribute to the • high-speed destruction of the rest of the explosive hollow charge and of the rest mechanisms, due to the increased momentum of the rocket grenade during its impact to the mentioned system.

In accordance with a further feature of the invention, with its way of operation is prevented the creation of accumulated bulky detonation wave of enormous temperature (plasma) , so as not to procure the catastrophic and deadly results.

…

2. The protection system according to claim 1, wherein said protection net is of steel sufficiently harceled to protect against self-propelled grenades.

3. The -protection system according to claim 1, wherein said protection net substantially prevents passage of a self-propelled grenade through said front side to said rear side.

4. The protection system according to claim 1, wherein said protection net is of steel sufficiently harceled to protect against armor-piercing shells.

5. The Protection system according to claim 1, wherein said protection net substantially prevents passage of an armor-piercing shell through said front side- to said rear side

6. The protection system according, to claim 1, wherein said net is configured to prevent the passing of an accumulated detonation plasma wave through said front side to said rear side.

Cut-away RPG-30. Photo from ARMS-TASS.

It uses a very clever system. A small rocket is launched from a secondary tube (mounted on the side of the main tube) moments before the 105mm PG-30 round. The smaller caliber round activate the active protection system early (and possibly detonate reactive armor) allowing the PG-30 round to smash through the armor plating. A simple and clever idea.

RPG-30 vs M1 Abrams. Click to expand. Image from WAFF.

The system weights 10.3 kg (I think that is unloaded).

ARMS-TASS reports (translated using Google):

MOSCOW, Nov. 19. (Korr.ARMS-TASS). A leading global developer in the area of munitions, the State Research and Production Enterprise (SPE), “Basalt, completed the development and testing of new anti-tank rocket RPG-30. This system is anti-tank weapons capable of overcoming any active protection systems (KAZ) vehicle created so far in various countries.

As explained korr.ARMS-TASS military experts, RPG-30 is designed for single use and represents a double device. In the large-diameter cylindrical container placed tandemnaya cumulative anti-grenade PG-30 caliber 105 mm. In the container of smaller diameter, located below, is a special projectile – a false goal. His appointment – to activate when podlete means of active air defense and create conditions for smooth penetration to the goal of the primary means of destruction – PG-30.

…

According to the military representative, the test program RPG-30 is fully completed. There are currently waiting for the RPG-30 by the Russian army and its inclusion in the list of No. 1, allowing the delivery of the product for export.

Looks like Western tanks could be in trouble. I expect Hugo Chávez will be all over this once it is approved for export.

Russian media report.

Hat Tip: WAFF

This video is the insurgent equivalent of the famously stupid “Girl Shoots Herself in the face” video (youtube has taken it offline).

Hat Tip: Charlie @ Ammo, Guns and War

Is it lawful to carry firearms?

This depends of several factors.

· Flag State your yacht is registered with.
· Area you are likely to operate in.
· Type of firearm.

If I were sailing around the world I would probably want to carry a pump action shotgun in 12 gauge and a bolt action rifle in a non military caliber such as 7mm-08 Rem., .260 Rem. or .270 Win.

Why?

Semi automatics are illegal or have various arbitrary restrictions in most of the world for civilians. At best it could be confiscated, at worst you could be fined or arrested.

Bolt actions are used all over the world and most countries will allow hunters or competition shooters to bring them into the country for sporting purposes. Military calibers are banned in some countries. Better to stick with something nobody is going to object to.

A removable magazine would be a plus and so would a stainless steel action and barrel. The Savage Weather Warrior Series Model 16FCSS in 7mm-08 would be my choice. It has a four round detachable magazine. I would be surprised if any countries has a problem with a four round magazine in a bolt action.

Some type of illuminated scope with quick detachable mounts and open sights would be a must.

Savage Model 16FCSS

Next up, a shotgun. A semi-automatic would be out for the same reason as the rifle. I am pretty sure pump actions are illegal in the UK, so if I were stopping by there then that would not be an option. The alternatives such as a double barrel, bolt action or lever action shotgun do not seem to me to be a credible threat to a ship full of pirates.

I would go with the Mossberg Mariner. At most I would install a magazine extension. Pimping it out withe pistol grips, fore grip and detachable magazines would not be a good idea.

Mossberg Mariner: A good idea.

Mossberg Mariner: A bad idea.

Lastly a replica RPG might not be a bad idea! Many years ago I was watching something on TV about super yachts and there was a brief clip of police somewhere in world showing off a cache of weapons they confiscated from super yachts including what looked like an M72 LAW. I am sure the LAW was not real.

Orange tipped replica.

My experience at sea is limited. I think the above would be good enough on small yacht. The aim really is to make it hard for pirates to come close while out maneuvering them.

I have traveled on very large cargo ships and defending them from pirates would be no different from defending a building.

What do you think about my ideas? Realistically what would you carry on the high seas?

A Chinese ship carrying 3 million rounds of 7.62×39mm and 1500 RPG rounds destined for land locked Zimbabwe tried to offload in the South African port of Durban.

Robert Mugabe’s Zanu (PF) party have been arming militias to drive out farmers and terrorize opposition supporters since the election they probably lost (but refuse to announce the results). Despite this the South African Defence Secretary approved the shipment: “This is a normal transaction between two sovereign states and we don’t have to interfere”. Not that surprising since the South African president openly supports Robert Mugabe.

Luckily for the people of Zimbabwe the dock workers have refused to offload the cargo.

Read the article here.

Poster from SearAndHammer.com

(and yes … I am aware this post does violate my non political rule

initiating threat warning, detection and localization within few seconds from a gunshot, rocket or a missile being launch, well before the threat reaches its target.

A few seconds seems quite a long time, I suppose it depends on its range but in an urban environment it seems useless when mounted on vehicles or buildings.

The RPG-7 used in Iraq is typically used at 50-100m. Its extreme range is about 300m. After 4.5 seconds of flights it self detonates. I cannot see how this optical locater device will help vehicles in Iraq against RPG fire.

Read more here.

Hat Tip: Danger Room